瀝青水泥撒布車常見故障及解決方法！_行業資訊_新聞中心-山東途暢路橋工程有限公司

行業資訊

瀝青水泥撒布車常見故障及解決方法！

來源：http://audisports.cn/ 日期：2020-11-30

瀝青水泥撒布車常見故障及解決方法

Common faults and solutions of asphalt cement spreader

1.柴油機不能持續起動超過5秒鐘以上，不能連續啟動三次以上，三次不能起動應檢查油路、電路。

1. If the diesel engine can not be started continuously for more than 5 seconds or more than three times, the oil circuit and circuit should be checked.

2.柴油機不起動，不能對瀝青泵預熱。

2. If the diesel engine does not start, the asphalt pump cannot be preheated.

3.充電顯示燈紅燈不亮表示發動機未對蓄電池充電，設備有故障，應對電路、電器進行檢修。

3. If the red light of the charging indicator light is not on, it means that the engine has not charged the battery, and the equipment has fault. Therefore, the circuit and electrical appliances should be overhauled.

4.如啟動機發生打滑現象，應調整啟動機支架位置

4. If the starter slips, adjust the position of the starter bracket
水泥撒布車出租

5.離合器離、合過程中，拉動離合器手柄能使離合器可靠平穩地分離和結合，不得有卡滯打滑現象。調整離合器分離杠桿與分離軸承的間隙可通過調整離合器軟軸拉線來實現。

5. In the process of clutch opening and closing, pulling the clutch handle can make the clutch separate and combine reliably and smoothly without jamming and slipping. The clearance between the clutch release lever and the release bearing can be adjusted by adjusting the clutch cable.

6.瀝青泵轉動開始還未噴瀝青

6. Asphalt has not been sprayed since the asphalt pump started to rotate

調整發動機轉速;

Adjust the engine speed;

檢查瀝青管路是否堵塞;

Check whether the asphalt pipeline is blocked;

瀝青進油管路中有空氣，可使瀝青泵運轉30秒鐘后排完空氣后吸油噴灑。

There is air in the asphalt oil inlet pipeline, which can make the asphalt pump run for 30 seconds and then absorb oil and spray after the air is finished.

上一條：冷再生機作業時的一些情況你知道嗎？

下一條：冷再生機租賃公司是如何使用乳化瀝青的呢？